混流泵

（一）   用途：

HW型混流泵為臥式、單級、單吸、懸臂蝸殼式混流泵，適用于農田排灌、工業、城鎮給排水及船塢、碼頭引水等。

I.                  

Application:

HW Spiral

Mixed-flow pump is a horizontal type, single stage, single suction and

cantilever spiral mixed flow pump, which is used for farmland irrigation and drainage,

industry, town water supply and drainage and water diversion of docks.

5、泵運轉時注意有無雜音及泵內是否有劇烈的磨擦和撞擊聲，如有就停車檢查。

When the pump is

running, pls pay more attetion on the noise and friction and clashing noise, if

there are strong noise, pls stop the pump to check.

    6、檢查進、出水管路有無進氣漏氣現象。

Check the

water-in and out pipes if they are leaking air.

    7、如電機與水泵為直聯傳動，需檢查電機與水泵的軸心線是否在同一直線上，以防轉時振動。

When the motor and pump are direct

connected drive ,check the motor and pump axile lead if they are in the same

line to avoid vibrating.

4、葉輪表面的氣蝕。由于葉片背水面運行時產生負壓，當壓力Pk<Pva時，產生汽穴和蜂窩表面后，在電化學腐蝕作用下，使泵葉汽蝕。

5、容積損失和機械損失。由于泵使用時間長，機械磨損產生漏失和阻力增大，使容積效率和機械效率降低。

以上原因，使水泵性能變差。運行效率降低2～5%，嚴重的可以使水泵效率降低10%以上。